Note that a tire shop will remove the tire and patch it. Tire, and Discount Tire stores will fix your flat tire. Tire shops such as NTB National Tire, Pep Boys, Mr. Instead, they remove the tire and patch it from the inside. Some tire shops do not offer this service. The average cost to plug a tire is between $15 and $30. If you drive on a run-flat tire that has lost air, the tire should be replaced and not plugged in. Can you plug a run-flat tire?Ī run-flat tire can be repaired only if you did not drive on a flat tire. It is ideal to have a patch plug because they are a more successful permanent repair. The reamer may make the hole too big for a patch plug some shops may not even attempt to repair the tire with a plug in it. If possible, get the tire to a shop to use a patch plug without having to put in a plug. If the hole is in the shoulder, a patch plug can not be used due to how it works. If the hole is inside the tire’s middle tread section and not the shoulder, it is ideal to use a patch plug. Should I use a patch plug or plug on my tire? How long does a tire plug last?Ī tire plug usually lasts the tire’s life, which can be over 40,000 miles. A proper patch plug is intended for more long-term and permanent use. It may last the tire’s life if it doesn’t leak over an extended period.
Keep an eye on a freshly plugged tire and see if it leaks. If no leaks are spotted, you’re done!Ī plugged tire is not ideal, but many outlast the tire’s life.
Once the hole is plugged, air up the tire and check for leaks. This situation is not ideal but can be done if a jack or tire iron is unavailable. It can be a bit more difficult to do this with the hole not being as easy to get to as when the tire is off the vehicle. Follow the same procedures starting at step 5 above for plugging the hole. Use the pliers to remove any nail or foreign object from the tire. Position the tire by either driving it or putting it in neutral and rolling it to get to a comfortable position where the hole can be worked on. Follow this procedure if the hole is exposed with the wheel on the vehicle: It is possible to plug a car tire while the tire is still on the vehicle. The sidewalls of the tire should not be plugged in. Remove the valve cap and spray water at the cap and inspect for leaks. If you can not find a nail, it is possible that the air leak is at the valve. Lower the car the rest of the way down and remove the jack. Torque the wheel nuts to the recommended specs. Lower the car down, so there is a little weight on the tire. Jack the car up and remove the jack stands. Put the lug nuts or studs back on and snug them down. Air up the tire to the recommended pressure and spray the hole to check for leaks if the plug job is successful, put the tire back on the vehicle. It is okay to leave it also it will wear off on its own after driving. Cut off any excess plug sticking out of the tire. Once the plug is completely in the tire’s hole, about a 1/4-1/2 inch inserted in the tire, pull the tool out of the tire, and the plug will stay. With a plugin, the insertion tool pushes the plug through the hole in the tire. Take a fresh plug and insert it halfway through the eyelet of the insertion tool. Work the reamer in and out of the hole 10-20 times to clean it and prepare it for the plug to be inserted. This can require great effort when the hole is small use your body weight pushing down toward the ground to puncture the tire. Take the reaming tool and push it through the hole. If there is a nail or screw in the tire, remove it with the pliers. Look for any bubbles forming to find the hole. If it is difficult to find the hole, ensure there is air in the tire and spray with a soapy water solution. Jack the tire off the ground and set the vehicle on jack stands. Loosen the lug nuts/studs of the wheel on the ground with the tire iron. Procedureįollow this procedure to plug a tire if the leak is not obvious: Tire plug kits are inexpensive and can be purchased that include the rasp, insertion, and plugs together. If you need to remove the tire from the car, you will need the following as well: 
To plug a tire while the wheel is still on the car, you will need:
0 kommentar(er)
